AVE-CCPS-01-IM
1 / 12ページ

INSTALLATION MANUAL Crystal Conforma AVE-CCPS-IM © 2017 Aveo Engineering Group, s.r.o. All rights reserved. The information contained within this document must not be disclosed, copied or reproduced in whole or in part without prior written permission from Aveo Engineering Group, s.r.o. Distribution of this document shall only be as stated in Table 02 unless otherwise agreed by Aveo Engineering Group, s.r.o.

Installation Manual AVE-CCPS-01-IM Issue 01 TABLE OF CONTENTS PART 0 0.1 0.2 0.3

Installation Manual AVE-CCPS-01-IM Issue 01 Document Administration Document Approval This document has been established in accordance with an alternative procedure to DOA approved under EASA AP429. This installation manual is applicable for following part numbers: Crystal Crystal Crystal Crystal Conforma Conforma Conforma Conforma (Red, Raised wingtip) (Green, Raised wingtip) (Red, Drooped wingtip) (Green, Drooped wingtip) Petr Jaroš Engineer, Aveo Engineering Group, s.r.o. Georg Hartl Head of DO, Aveo Engineering Group, s.r.o. Amendment Record Procedure The master copy of this document...

Installation Manual AVE-CCPS-01-IM Issue 01 Effected Pages Procedure ALL pages affected by ANY raise of issue of this manual will be listed in Table 01 - Effected Pages Column. The reason(s) for EACH raise of issue and the description of respective change will be provided in Table 01 - Details Column. Changes from the previous issue are shown as follows: a) new text is highlighted with yellow shading: new b) deleted text is shown with yellow shading and a strike through: deleted

Installation Manual AVE-CCPS-01-IM Issue 01 Installation data Crystal Conforma Crystal Conforma™ is the ultimate ALL-IN-ONE wingtip module for aircraft. This light provides Position and Strobe Light per ETSO standards. Crystal Crystal Crystal Crystal Conforma Conforma Conforma Conforma (Red, Raised wingtip) (Green, Raised wingtip) (Red, Drooped wingtip) (Green, Drooped wingtip)

Installation Manual AVE-CCPS-01-IM Issue 01 Operating Instructions When installed on the aircraft, using the aircraft’s power (14 and 28 volts), the light will be at its maximum intensity. Operating voltage range is 9 to 36 V DC. Wire type: Wire length: Installation Schematic / Wiring Diagram multicores 22 AWG, 600 V insulation, 200°C rating; 30“ minimum (770 mm minimum)

Installation Manual AVE-CCPS-01-IM Issue 01 Control & Power Inputs Red Yellow Black Blue Brown Nav. Steady Anti-collision Strobe V DC, return VRTN preheating stand-by power Technical Specification Operating Voltage Range: Output power, not less than: - navigation - steady green pulse strobe white Input power, not more than: - navigation - steady green pulse strobe white 0.39 A max preheating, 72 Ohm resistive warming element (serial 36 x 2 Ohm, P=0.5 W per resistor, max. power 11W). 1. Output current, not less than: - navigation steady white strobe Repetition Flash Rate of Strobe: Low...

Installation Manual AVE-CCPS-01-IM Issue 01 c. Over-voltage lockout: Technical Drawing

Installation Manual AVE-CCPS-01-IM Issue 01 Wiring Chart

Installation Manual AVE-CCPS-01-IM Issue 01 Equipment Limitation Crystal Conforma should only be powered by 9-36 V DC. Care and Cleaning of Lights Aveo Engineering Aviation Lights are factory polished and delivered as ready to install on the aircraft. If the lights need a deeper cleaning, they should be polished with a quality lamb’s wool sheet that is suitable also for deeper polishing. Under no circumstances should any petroleum based product be used to clean the lights. 1.10 Testing the Lights before Installation All Aveo Aviation lights undergo rigorous testing prior to being released...

Installation Manual AVE-CCPS-01-IM Issue 01 When installed on the aircraft and using the aircraft’s power (28 volts), the light will be at its maximum intensity. If the tests are successfully completed, the lights can be installed on the aircraft. IMPORTANT NOTES: Under no circumstances should any power supply other than a 9-36V DC, or a 28 volt battery be used to test the light. Do not use: Battery chargers, battery back-up power devices, or other bench avionics testing methods to test the aviation light. The light is functional between 9 and 36 volts. Use of a battery charger or other...

Installation Manual AVE-CCPS-01-IM Issue 01 tripled and thereby provide an even great margin of safety for continued airworthiness due to the dramatic enhancement of electronics reliability. b. Periodic Inspection Procedure The Crystal Conforma lights should always be checked for proper operation during preflight. This procedural information is already provided in all general aviation aircraft flight manuals. The lights should be visually examined for general condition, proper operation, and correct installation at each inspection to be carried out annually and/or after 100 hours of...