Exceleron DayLite
1 / 13Pagine

INSTALLATION MANUAL © Aveo Engineering Group, s.r.o. All rights reserved. The information contained within this document must not be disclosed, copied or reproduced in whole or in part without prior written permission from Aveo Engineering Group, s.r.o. Distribution of this document shall only be as stated in Table 02 unless otherwise agreed by Aveo Engineering Group, s.r.o.

INSTALLATION MANUAL Exceleron DayLiteTM AVE-EX9-IM Issue 01

Exceleron DayLiteTM AVE-EX9-IM Issue 01 INSTALLATION MANUAL Manual Administration Document approval This document has been established in accordance with an alternative procedure to DOA approved under EASA AP429. This installation manual is applicable for part numbers: • • • • • • Exceleron Exceleron Exceleron Exceleron Exceleron Exceleron DayLite DayLite DayLite DayLite DayLite DayLite Landing (9°) Landing (12°) Landing (9x10.5°) Landing (9x10°) Taxi (12x30°) Taxi (20°) Petr Jaroš Engineer, Aveo Engineering Group, s.r.o. Georg Hartl Head of DO, Aveo Engineering Group, s.r.o.

Exceleron DayLiteTM AVE-EX9-IM Issue 01 INSTALLATION MANUAL Amendment Record procedure The master copy of this document shall be kept electronically as a read only document under the control of Aveo Engineering Group, s.r.o. as Master Copy. ALL amendments to this manual will initiate a raise of issue. ALL raises of issue will be given a sequential Alphabetic Issue Ident sequentially from 01 to 99 in Table 01 - Issue No: Column– Initial Issue of Document will be “01” ALL Issues of this document will be approved by Head of DO Affected Pages Initial Issue Table 01: Document Amendment Record...

Exceleron DayLiteTM AVE-EX9-IM Issue 01 INSTALLATION MANUAL Installation data Exceleron DayLite The Exceleron DayLite™ landing or taxi light is a high powered LED light use in GA and transport category aircraft. It has been designed to be lightweight and with a low power draw to meet the highest requirements of all certified aircraft. • • • • • • Exceleron Exceleron Exceleron Exceleron Exceleron Exceleron DayLite DayLite DayLite DayLite DayLite DayLite Landing (9°) Landing (12°) Landing (9x10.5°) Landing (9x10°) Taxi (12x30°) Taxi (20°) Operating Instructions When installed on the aircraft,...

Exceleron DayLiteTM AVE-EX9-IM Issue 01 INSTALLATION MANUAL Technical Specification Electronic specification - Ambient temperature (25°C): Operating voltage: Voltage protection: Reverse polarity protection: LED quantity: Performance: Input current: Input power: Operating temperature: Over-Temperature protection: Weight: 9-36V DC a. Over-voltage protection: 80V/1s b. Over-voltage lockout: 38.5V c. Under-Voltage protection: 7V Yes 6 pcs 2.13A @14V DC 1.06A @28V DC 29.8W @14V DC 29.8W @28V DC -55°C to +85°C / -67°F to +185°F Yes 7.936 oz (225 g) Technical Drawing

INSTALLATION MANUAL Exceleron DayLiteTM AVE-EX9-IM Issue 01 Wiring Chart Use diagram below defining the wiring size depending on the current and the wire length. Make sure you add up the current for all connected lights. If current is not given, then divide the power by the voltage.

Exceleron DayLiteTM AVE-EX9-IM Issue 01 INSTALLATION MANUAL Optic Simulation Exceleron DayLite LANDING (9°) Exceleron DayLite LANDING (12°)

Exceleron DayLiteTM AVE-EX9-IM Issue 01 INSTALLATION MANUAL Exceleron DayLite LANDING (9x10.5°) Exceleron DayLite LANDING (9x10°)

Exceleron DayLiteTM AVE-EX9-IM Issue 01 INSTALLATION MANUAL Exceleron DayLite TAXI (12x30°) Exceleron DayLite TAXI (20°)

Exceleron DayLiteTM AVE-EX9-IM Issue 01 INSTALLATION MANUAL Equipment Limitation Exceleron DayLite™ should only be powered by 9-36VDC. Care and Cleaning of Lights Aveo Engineering Aviation Lights are factory polished and delivered as ready to install on the aircraft. If the lights need a deeper cleaning, they should be polished with a quality lamb’s wool sheet that is suitable also for deeper polishing. Under no circumstances should any petroleum based product be used to clean the lights. Testing the Lights before Installation All Aveo Aviation lights undergo rigorous testing prior to being...

INSTALLATION MANUAL Exceleron DayLiteTM AVE-EX9-IM Issue 01 IMPORTANT NOTES: Under no circumstances should any power supply other than a 9-36V DC, or a 14 or 28 Volt battery be used to test the light. Do not use: Battery chargers, battery back-up power devices, or other bench avionics testing methods to test the aviation light. The light is functional between 9 and 36 volts. Use of a battery charger or other power unit to test the light will void the warranty and may damage the light. If you have any questions about the installation of the lights, please refer to our web site:...

INSTALLATION MANUAL Exceleron DayLiteTM AVE-EX9-IM Issue 01 RoHS Compliance Statement This statement clarifies Aveo Engineering’s compliance with European Union Directive 2015/863/EU on the restriction of the use of certain hazardous substances in electrical and electronic equipment ("RoHS") that took effect on June 4, 2015. The RoHS Directive restricts the sale of electronic equipment containing certain hazardous substances in the European Union including: Cadmium(Cd): 0.01% Mercury: 0.1% Lead(Pb) : 0.1% Hexavalent chromium (Cr6+) : 0.1% Polybrominated biphenyls (PBB): 0.1 %;...