Ultra Galactica
1 / 13Seiten

INSTALLATION MANUAL © Aveo Engineering Group, s.r.o. All rights reserved. The information contained within this document must not be disclosed, copied or reproduced in whole or in part without prior written permission from Aveo Engineering Group, s.r.o.

Installation Manual AVE-WPST-54G-IM Issue 05 TABLE OF CONTENTS PART 0 0.1 0.2 0.3

Installation Manual AVE-WPST-54G-IM Issue 05 Document Administration Document Approval This document has been established in accordance with an alternative procedure to DOA approved under EASA AP429. This installation manual is applicable for following part numbers (Modification status Mod(4) or higher): • • Ultra Galactica (Red) Ultra Galactica (Green) Petr Jaroš Engineer, Aveo Engineering Group, s.r.o. Georg Hartl Head of DO, Aveo Engineering Group, s.r.o.

Installation Manual AVE-WPST-54G-IM Issue 05 Amendment Record Procedure The master copy of this document shall be kept electronically as a read only document under the control of Aveo Engineering Group, s.r.o. as Master Copy. ALL amendments to this manual will initiate a raise of issue. The original issue will be identified by “01”, and subsequent issues will be numbered sequentially from 02 to 99 in Table 01 - Issue No. column. ALL issues of this document will be approved by Head of DO. Issue No. Effected Pages Initial Issue Addition of FAA required statements Change in category of section...

Installation Manual AVE-WPST-54G-IM Issue 05 Installation data Ultra Galactica ™ The Ultra series lights are a very popular choice for certified and general aviation aircraft of any size, due to their compact design and easy installation. With full optical testing for brightness and chromaticity, the Ultra also underwent the rigorous DO-160 testing regime and was recognized as exceeding all requirements. The Ultra has also become the leading wing light solution for numerous military and law enforcement/surveillance UAVs around the world and is very popular with aircraft manufacturers....

Installation Manual AVE-WPST-54G-IM Issue 05 Operating Instructions When installed on the aircraft, using the aircraft’s power (14 or 28 volts), the Ultra Galactica light will be at its maximum intensity. It meets the requirements of ETSO-C30c (Aircraft Position Light, SAE A S S017 rev. B, SAE A S 8037 rev. A) and ETSO-C96a (Anticollision Light System). The light operates within the range of voltage from 9 V to 36 V DC. 1.3 Installation Schematic / Wiring Diagram WIRES: Teflon insulation, 500V, AWG 20, 22 Wire length from base of unit 254mm [10.00 inch] min. 1.4 VCCP VCCS GND SYNC -...

Installation Manual AVE-WPST-54G-IM Issue 05 Technical Specification Weight: Operating voltage range: Operating temperature: Power: - Position branch (red), input power: § 9 V / 0.55 A: Strobe branch (left), input power: § 9 V / 6.49 A: § 14 V / 2.97 A: § 28 V / 1.38 A: § 36 V / 1.07 A: Position branch (green), input power: § 9 V / 0.56 A: § 14 V / 0.36 A: § 28 V / 0.19 A: § 36 V / 0.15 A: Strobe branch (right), input power: § 9 V / 6.33 A: § 14 V / 2.92 A: § 28 V / 1.36 A: § 36 V / 1.06 A: Repetition Flash Rate of Strobe: Recommended size of mounting screws: Meets and exceeds requirements...

Installation Manual AVE-WPST-54G-IM Issue 05 Technical Drawing

Installation Manual AVE-WPST-54G-IM Issue 05 Wiring Chart Equipment Limitation Ultra Galactica™ should only be powered by 9-36 V DC, typically a 12V or 24V aircraft battery. This article meets the minimum performance and quality control standards required by the technical standard orders ETSO C30c and ETSO C96a. Installation of this article requires separate approval. Deviations This article deviates from ETSO C30c and ETSO C96a by the usage of newer revisions of the following standards: • SAE AS 8017 rev. B used instead of SAE AS 8017 rev. A, • SAE AS 8037 rev. A used instead of SAE AS...

Installation Manual AVE-WPST-54G-IM Issue 05 Testing the Lights before Installation All Aveo Aviation lights undergo rigorous testing prior to being released from our engineering manufacturing department. This testing involves a burn-in time as well as other function testing. No light is released for sale without undergoing this extensive operational testing. When you receive the Ultra Galactica light, and wish to test the function of the light prior to installation on your aircraft, please observe the following procedure: 1. Review the written information that is enclosed in the packaging....

Installation Manual AVE-WPST-54G-IM Issue 05 If you have any questions regarding the installation of the lights, please refer to our web site: www.aveoengineering.com and check FAQ and other links on our aviation lights web page. Stainless steel M5 x 40 mm (DIN7984) or equivalent screws are recommended to be used for installation. Screw length depends on placement of screws on wingtips. Care and Cleaning of Lights Aveo Engineering Aviation Lights are factory polished and delivered as ready to install on the aircraft. Upon installation, apply one or two coats of quality automotive polish....

Installation Manual AVE-WPST-54G-IM Issue 05 The lights should be visually examined for general condition, proper operation, and correct installation at each inspection to be carried out annually and/or after 100 hours of operation. Any debris or atmospheric deposits accumulated on the surface of the lights should be removed using a UV Wax such as Farecia Profile UV Wax to ensure ongoing optical clarity. In addition, refer to section 1.11 of installation manual for detailed cleaning instructions. The following procedure shall be performed, firstly, in the steady mode and secondly, in the...

Installation Manual AVE-WPST-54G-IM Issue 05 Figure 4: Position LEDs (white) RoHS Compliance Statement This statement clarifies Aveo Engineering’s compliance with European Union Directive 2015/863/EU on the restriction of the use of certain hazardous substances in electrical and electronic equipment ("RoHS") that took effect on June 4, 2015. The RoHS Directive restricts the sale of electronic equipment containing certain hazardous substances in the European Union including: Cadmium(Cd): 0.01% Mercury: 0.1% Lead(Pb): 0.1% Hexavalent chromium (Cr6+): 0.1% Polybrominated biphenyls (PBB): 0.1...